Difransiyeli Dağıttım.....

  • Konuyu Başlatan Konuyu Başlatan smoke
  • Başlangıç tarihi Başlangıç tarihi
çok şanslısın gece nhafta b musterımınkıde o dişliyı kırdı ancak o 90 km hızla gıderken kırdı. şanzuman her yerınden patlattı 700 ytl ye sanzuman bulduk. çok şanslısın.
 
geçmiş olsun
 
Geçmiş olsun walla...
 
umarım ATF koymamışsınızdır.
 
geçmiş olsun kardeş
bir sadaka bin belayı def eder.
 
Büyük geçmiş olsun.
 
geçmiş olsun...
sayende bizde tecrübe kazandık...
 
geçmiş olsun valla film gibi
 
VAT Registration No.:
Notes Specified value Measured value
VEHICLE IDENTIFICATION
No. of cylinders Type 4/DOHC
Capacity (Fiscal) cc 1798
Compression ratio :1 10,8
Output kW (DIN hp) rpm 85 (115) 5400
Suitable for unleaded petrol Yes
Minimum octane rating RON 95
Ignition system Description Map-DIS
Ignition system Type Simtec 56.1
Trigger location Cam/Crankshaft
Fuel System Description MFI-s
Carburettor/Injection system Make Siemens
Carburettor/Injection system Type Simtec 56.1
Air metering Type Mass
Combined ignition and fuel ECM Yes
Diagnostic socket Yes
IGNITION SYSTEM
Ignition coil supply voltage + with ballast V 11,0
Primary resistance Ohm 0,5
Secondary resistance Ohm 7000
Distributor (ECM) Make Siemens
Firing order 1-3-4-2
Ignition timing - basic BTDC °Engine/rpm Not adjustable
Ignition advance checks °Engine/rpm ECM controlled
TUNING AND EMISSIONS
Idle speed rpm 700-1000
Not adjustable
Oil temperature for CO test °C 80
CO level at idle speed - tailpipe Vol. % CO Not adjustable
CO level at idle speed - tailpipe (Cat) Vol. % CO 0,4 Max
HC level at idle speed ppm 100
CO2 level at idle speed Vol. % CO2 14,5-16
O2 level at idle speed Vol. % O2 0,1-0,5
Increased idle speed for CO test rpm 2800-3200
CO content at increased idle speed % Vol 0,3
Lambda at increased idle lambda 0,97-1,03
SPARK PLUGS
Spark plugs Original equipment Bosch
Spark plug Type FR8LDC
Electrode gap mm 0,8
Spark plugs Make Bosch
Spark plug Type FR8LDC
Electrode gap mm 0,8
Spark plugs Make Champion
Spark plug Type RC10DMC
Spark plugs Make NGK
Spark plug Type BKR6EK
Electrode gap mm 0,8
Spark plugs Make Beru
Spark plug Type 14FLR-8LDUX
Electrode gap mm 1,0
FUEL SYSTEM
System pressure without vacuum bar 2,9-3,1
Regulated pressure with vacuum bar 2,2-2,4
Coolant temperature sensor Ohm/°C 300-360/80
RPM/TDC sensor resistance Ohm 12-12,5
Manufacturer: Opel/Vauxhall Model: Astra-F 1,8 16V
Engine code: C18XEL Output: 85 (115) 5400
Tuned for: R-Cat Year: 1994-98
© Autodata Limited 2001
26.02.2005
V3.022-
Injector opening duration (hot) ms/rpm 1,9-3,1/850
Oxygen sensor heater resistance Ohm 4-5
SERVICE ADJUSTMENTS
Valve clearance -INLET mm Hydraulic
Valve clearance -EXHAUST mm Hydraulic
Compression pressure bar 12-15
Oil pressure bar/rpm 2,0/850
Drive belt size - PAS/AC mm 6K 1725/6K 1900
Drive belt size AC mm 6Kx1900
LUBRICANTS AND CAPACITIES
Engine oil grade - Cold climate SAE 5W/30
Engine oil grade - Moderate climate SAE 15W/40
Engine oil classification - Moderate climate API/ACEA SJ/A2-96
Engine oil grade alternative - Moderate climate SAE 10W/40 Semi-synth.
Engine oil classification alternative - Moderate climate API/ACEA SJ/A3-96
Engine oil grade - Hot climate SAE 20W/40
Engine with filter litres 4,0
Gearbox oil grade SAE 80W
Gearbox 4/5 speed litres 1,9
Cooling system litres 6,9
TIGHTENING TORQUES
Cylinder head
Cylinder head instructions
Renew bolts Yes
Stage 1 Tighten 25 Nm
Stage 2 Tighten 90°
Stage 3 Tighten 90°
Stage 4 Tighten 90°
Other tightening torques
Main bearings Renew bolts
Main bearings Stage 1 50 Nm
Main bearings Stage 2 45°-60°
Big end bearings Renew bolts
Big end bearings Stage 1 35 Nm
Big end bearings Stage 2 45°-50°
1 Flywheel/Driveplate
Oil pump to cylinder block 8 Nm
2 Sump bolts
3 Sump drain bolt
Clutch to flywheel 15 Nm
4 Crankshaft pulley
5 Camshaft sprocket/gear
Camshaft carrier/cap 8 Nm
Camshaft/rocker cover 8 Nm
Inlet manifold to cylinder head 22 Nm
Exhaust manifold to cylinder head 22 Nm
Spark plugs 25 Nm
Lambda probe (oxygen sensor) 30 Nm
Knock sensor 25 Nm
6 Front hub
7 Steering track rod end 60 Nm
Brake caliper to carrier Front 30 Nm
Brake caliper carrier to hub Front 95 Nm
Brake caliper carrier to hub Rear 80 Nm
ABS Sensor Front 8 Nm
ABS Sensor Rear 8 Nm
Road wheels 110 Nm
STARTING AND CHARGING
Battery V/RC(Ah) 12/65 (44)
Starter motor Make Bosch
Starter motor Type 0 001 108 079
Maximum cranking amps A 119-145
Alternator/Regulator Make Delco
Alternator/Regulator Type 10 479 947
Alternator output at engine speed A/V/rpm 70/14/6000
Regulated voltage V 14,2-15,2
Manufacturer: Opel/Vauxhall Model: Astra-F 1,8 16V
Engine code: C18XEL Output: 85 (115) 5400
Tuned for: R-Cat Year: 1994-98
© Autodata Limited 2001
26.02.2005
V3.022-
BRAKE DISC AND DRUM DIMENSIONS
Minimum disc thickness - ventilated Front 21 mm
Minimum disc thickness Rear 7 mm
Disc thickness variation Front 0,010 mm
Disc thickness variation Rear 0,010 mm
Disc runout Front 0,10 mm
Disc runout Rear 0,10 mm
Minimum pad thickness Front 7 mm
8 Minimum pad thickness Rear 7 mm
Handbrake travel No. of notches 7
AIR CONDITIONING
Air conditioning refrigerant type R134a
9 Air conditioning refrigerant quantity grams
Air conditioning oil type PAG
Air conditioning oil quantity cmі 295
Autodata Note 1
Flywheel/drive plate
Use new bolts and tighten to
65 Nm + 30° + 15°.
Tighten drive plate to 60 Nm.
Autodata Note 2
Sump bolts
Sump lower part to block = 20 Nm
Sump upper part to block = 40 Nm
Sump upper part to transmission = 20 Nm.
Autodata Note 3
Sump drain bolt
Torx bolt = 10-15 Nm
Hexagonal bolt = 45-55 Nm.
Autodata Note 4
Crankshaft pulley
Use new bolts and tighten centre bolt to the
following torque:
130 Nm + 40°-50°.
Autodata Note 5
Camshaft sprocket
Use new bolts, tighten in the following stages:
1) 50 Nm
2) 60°
3) 15°.
Autodata Note 6
Front hub nut
Use new nut and washer.
Tighten in three stages:
1) 100 Nm
2) Slacken off
3) 20 Nm + 80°-90°.
Autodata Note 7
Use new bolts/nuts.
Autodata Note 8
Minimum pad/shoe thickness
Measurement includes lining and pad/shoe backing
plate.
Manufacturer: Opel/Vauxhall Model: Astra-F 1,8 16V
Engine code: C18XEL Output: 85 (115) 5400
Tuned for: R-Cat Year: 1994-98
© Autodata Limited 2001
26.02.2005
V3.022-
Autodata Note 9
Refrigerant quantity
1991-94 = 700 grams
1994-98 = 900 grams.
Tightening sequence
Manufacturer: Opel/Vauxhall Model: Astra-F 1,8 16V
Engine code: C18XEL Output: 85 (115) 5400
Tuned for: R-Cat Year: 1994-98
 
Cevap yazmak için giriş yap yada kayıt ol.
Geri
Üst